Using outboard gas tank for generator

Outboard tanks dont gravity feed. Ok I run two outboards on my boat and have 2 150 gal tanks with the manifold system from the factory I can run either engine from either tank or both in any combination I choose.

After hurricane Andrew I used my boat six gallon tanks to supply gas for my generator.

Using outboard gas tank for generator. Option 1 Purpose built external fuel tank for your generator. Simply buy something purpose built for your brand of generator that flows the gas from an external tank. This one connects to a generator eg.

The Honda through a special fuel tank cap and into the internal tank of the generator. As the vacuum builds up in the internal fuel tank for the Honda it will pull fuel from the extended tank. Mark the generator tank so that oil will not get added to it by mistake like the outboard tank.

The Honda does not require a fueloil mix. The Honda will now run for a much longer time and annoy your neighbors for hours. There are many.

I use an outboard motor tank as an aux generator tank. It rests on top of the generator fuel tank and feeds into the carb by gravity. Upvote 12 08-19-09 0529 AM ray2047.

33581 Received 14 Votes on 12 Posts Given all the fed and state road taxes when you initially purchase gasoline plus your. After hurricane Andrew I used my boat six gallon tanks to supply gas for my generator. I put a stool alongside of the generator.

I put one end of a rubber marine fuel line into the tank through the fill cap opening. To that end I tied a heavy bolt to keep the line from popping out. Screw your generator gas cap with fitting back onto your generator.

12 Set the marine tank beside the generator at least three feet away if possible. 13 Get your marine ballpump and hose. This is going to be the line you connect the tank and the generator with.

Before connecting it up look for the direction arrow on the pump and install the. Take the marine ball pump and hose and with the arrow on it pointing towards the generator connect the generator and the fuel tank. They should ideally be three feet apart.

Your going to need either a twin feed from the tank a fuel valve to switch between motors or check valves in line. You can pump up the fuel and start the motor but then the running engine will draw from the engines line not running. Easies way would be to put in a valve if your tank does not have an additional feed port.

Outboards have a fuel pump which draws fuel from the tank. Even modern above-deck sealed tanks which generate excessive pressure have an on-demand valve so fuel is only delivered when drawn from the tank by the engine. Your fuel pump may need a quick rebuild - check iboats or ebay for a kit and Youtube for a video showing how.

The following is a partial list of Porter Cable Portable Generators model numbers that are using the GS-0444 plastic extended run 7 gallon gas fuel tank. These portable generators were sold under the Porter Cable brand name and were sold by various stores including Home Depot Lowes Menards Ace hardware Costco Wal-Mart Sams Club Sears stores Carter Lumber and other fine retailers. What Youll Need.

1 marine gas tank. 2 plastic marine fittings. 1 marine hose wsqueeze ball.

Adding an auxiliary fuel tank to a generator may be necessary in the case when your current generator is unable to operate on its single tank. The addition of an auxiliary fuel tank allows the generator to continue running once fuel. I use outboard tanks for the couple of generators that I have that are still setup to burn gasoline and they work great.

Just dont use them for gravity feeding unless you have good fire. Out of all secondary parts besides the best transom savers best underwater boat lights etc for any marine owner a portable marine fuel tank is a must-have unit if you have a vessel with an outboard motorLarge watercrafts come with integrated gas tanks while smaller vessels require a separate smaller tank. REMOVE RUST FROM YOUR GAS TANK THE CHEAP EASY WAY - YouTube.

Ok I run two outboards on my boat and have 2 150 gal tanks with the manifold system from the factory I can run either engine from either tank or both in any combination I choose. The system is simple you need to install a 3-way valve from your tank and connect both lines to it. You now can select which engine will get fuel.

Honda code 371327876697578837908369007076275408157174 Tank is 12 liter larger than OEM for GX240 and GX270 Not compatible with greater than 10 ethanol fuel. GX240 GX270 GX340 and GX390. For 8 9 11 and 13 HP engines.

Using gasoline for electrical generation mechanical power or propulsion including outboard boats. 24 DEFINITIONS For the purposes of this standard the following definitions apply. Ventilation guidelines for boats using diesel fuel are contained in ABYC H-32 Ventilation of Boats Using Diesel Fuel.

The first length should be approximately two feet in length and the second should be long enough to reach from your intended gas can location to the outboard motor itself. Step 3 Insert the two-foot length of fuel line into the hole you drilled in the gas cap so that six inches of fuel line will extend out of the top of the cap when it is screwed onto the fuel tank. All outboard motors have vented gas tanks.

As the fuel pump sucks fuel out of the tank the fuels departure creates a small vacuum inside the tank. If there was no way to fill that vacuum it might overcome the pressure of the fuel pump and your motor would starve for want of gas. Some outboard gas tanks have a vent that opens as pressure inside.

Converting a small outboard to a remote gas tank - YouTube. Converting a small outboard to a remote gas tank. If playback doesnt.

Outboard fuel tanks are made from has a number Of notable attributes. Like fiberglass provided its properly manufactured and installed its virtually proof and is highly unlikely to otherwise fail structurally. Most XPE fuel tanks are mtationally molded which makes them seamless and thus virtually leak proof.

Outboard tanks dont gravity feed. They need a fuel pump to pull the fuel up the pickup tube. You should able to get a siphon going though.

If you put a fitting in the top of your gas tank and there were no air leaks that might work. If the generator has a fuel pump hook the ob tank directly the the inlet. In the past I have connected 2 tanks together with fittings screwed into the bottom of each tank and then connecting them together with a hose its been my experience that the fuel levels equalise perfectly through the interconnecting hose while the engine is drawing fuel from one of the tanks and when the engine eventually runs out of fuel both tanks are dry like this there are no airlock issues that you get with siphons the fuel.

Gas can adapter for outboards. One reason the cans made for the job are better is their low profile. No risk of the can turning over in the boat.

And the sending unit is securely attached.