Detroit diesel water pump removal

If damaged replace the water pump. Place containers to catch coolant at draining locations.

Some people told me there was a.

Detroit diesel water pump removal. Ad Huge stock of Detroit Diesel parts. About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy Safety How YouTube works Test new features Press Copyright Contact us Creators. Replacing a Water Pump in a Detroit DD Engine - YouTube.

Series 60 Detroit water pump removal with EGR - YouTube. Drain Coolant Remove the shunt linehard metal line Remove the line on the bottom of the water pump going to the Air Compressor. Remove the metal elbow and hose going to the EGR cooler Be carefull keep a pan under it you will lose alot of antifreeze here.

Remove all the fittings going into the water pumpthis makes it easier to wiggle out. Draining and Removal of Water Pump GCM Drain the cooling system as follows Open the drain cocks located at the right rear corner of the engine at the bottom of the water pump and in the bottom of the thermostat housing Remove the water pump as follows Loosen the hose clamps and remove the coolant hoses from the water pump housing. DDFP Detroit Diesel Engines approved for Fire Pump Service.

Raw water from the fire pump passes through a tube bundle in the heat e xchanger to remove the heat from the engine coolant. Fuel is drawn from the supply tank through a strainer by a gear-type fuel pump. It is then forced through a filter and into.

Clamp the water pump drive gear in a vise with the impeller facing up. Use a two-screw gear puller and remove the water pump impeller from the shaft using the two threaded holes in the impeller. Hold square end of water pump shaft and remove water pump drive gear retaining bolt and washer.

Remove the pressure cap. Drain radiator from the petcock bottom left corner on a Freightliner. If there is no petcock drain from the bottom radiator hose using a screwdriver to provide a drain path.

While coolant is draining remove air filter and ducting. Close radiator petcock if there is one. Pull off bottom radiator hose completely.

I show you how step by step to removal and install a new water pump on2018 Freightliner cascadia truckTractor with Detroit Diesel DD15 engineBuy Me Lunchh. Use a two-screw puller and remove the water pump impeller from the shaft using the two threaded holes in the face of the impeller. Place the water pump face down on a press bed.

Using J359885A part of tool set J35988C and two breaker bars loosen the locknut that secures the water pump drive gear to the shaft. Detroit Diesel Raw water pump repair kit for 6-71 8V71 8V53 12V71 6V92 8V92. For 3 12 height impeller - spline pump shaft.

Detroit Series 60 Water Pump Replacement Replacing your Series 60 Water pump is necessary to the overall health of your engine. When this part breaks down it can cause overheating which can lead to serious damage to the power system. Luckily we have a water pump that built to last out of high quality materials and ready to be used right away.

Remove the front connector housing and gasket from the cylinder head. Remove the water pump connector fitting from the water pump. Remove the rocker arm assembly.

Mark the pushrods in order of removal. Remove the valve bridges. Section 118Faulty Water Pump.

Remove the water pump. Refer to the EPA07 DD15 Workshop Manual DDC-SVC-MAN-0002 cooling system chapter. Inspect the pulley shaft and impeller for damage.

If damaged replace the water pump. To avoid injury from inhaling engine exhaust always operate the engine in a well-ventilated area. Detroit Diesel water pumps for 8V92 engines are all in one place.

How to find order and ship the water pump for your Detroit Diesel 8V92 is fast and easy on our site. With 24hrs shipping you engine is back to work in no time. Detroitdieselbus silvereagle bus bus I Had such a hard time figuring out how to get this pulley off without damaging it.

Some people told me there was a. Genuine BIG Machine Parts replacement water pump for trucks equipped with Detroit Diesel DD13 and DD15 Engines. Quality engineered and lab tested our Detroit Diesel Water Pump will restore proper coolant circulation to your Freightliner truck.

One Year 100000 Mile Warranty is standard for Freightliner truck parts. One 1 Water Pump. The engine must be cool to efficiently remove the water-based coolant because the plug for draining the block is in a confined location that can burn your hand.

Place containers to catch coolant at draining locations. Remove the pressure cap. Remove the front engine mount by removing the four bolts securing the front engine mount to the gear case cover.

Loosen and remove the five bolts that secure the accessory drive assembly to the gear case cover. Ad Huge stock of Detroit Diesel parts.